Product ID:CARBON DIOXIDE,GAS
MSDS Date:08/04/1989
FSC:4220
NIIN:00-535-7231
MSDS Number: BZJGP

Emergency Phone: 908-464-8100/800-424-9300(CHEMTREC)

Info Phone: 908-464-8100

Cage: 00741

Telephone: 800-424-9300(CHEMTREC)

Cage: 0ZGE6

CARBON DIOXIDE

CAS: 124-38-9

RTECS: FF6400000

Fraction By Weight: >=99.8%

OSHA PEL 5000 PPM

ACGIH TLV: 5000PPM/30000STEL;96

LD50 LC50 Mixture:TLV IS 5000 PPM.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:LUNGS, HEART, CNS, EYES,
SKIN. ACUTE- CONTACT WITH LIQUID CAN CAUSE SKIN FROSTBITE. GAS MAY
CAUSE EYE IRRITATION. ASPHYXIANT. INHALATION MAY CAUSE RESPIRATORY
ACIDOSIS. HIGH CONCENTRATIO NS MAY CAUSE RAPID CIRCULATORY
INSUFFICIENCY LEADING TO DEATH. INGESTION UNLIKELY. CHRONIC-
UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, FROSTBITE, HEADACHE, DROWSINESS,
DIZZINESS, STINGING OF THE EYES, NOSE AND THROAT, EXCITATION, RAPID
BREATHING AND HEART RATE, EXCESS SALIVATION, SHORTNESS OF BREATH,
MUSCULAR WEAKNESS, RI NGING IN THE EAR, UNCONSCIOUSNESS, COMA,
NAUSEA, VOMITING, WATERY EYES (FORMATION OF WEAK CABONIC ACID)
Medical Cond Aggravated by Exposure:PERSONNEL WITH PRE-EXISTING CHRONIC
RESPIRATORY DISEASES OR HEART DISORDERS SHOULD REFRAIN FROM
BREATHING EXCESSIVE CARBON DIOXIDE.

First Aid:INHALATION:REMOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED.
EYES:IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SEE AN
OPHTHALMOLOGIST, URGENTLY. SKIN:FLUSH WITH WARM WATER (NOT TO
EXCEED 107 F). PROMPT MEDICAL ATTENTION IS MANDATORY IN ALL CASES
OF OVEREXPOSURE TO CO2. RESCUE PERSONNEL SHOULD BE EQUIPPED WITH
SELF CONTAINED BREATHING APPARATUS. ORAL:TREAT SYMPTOMATICALLY.
CALL PHYSICIAN.

Flash Point:NONE
Extinguishing Media:CARBON DIOXIDE CANNOT CATCH FIRE. USE WATER FOG,
CARBON DIOXIDE, FOAM, OR DRY CHEMICAL FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
NIOSH-APPROVED SELF CONTAINED BREATHING APPARATUS. COOL FIRE
EXPOSED CONTAINERS WITH WATER SPRAY. EVACUATE AREA.
Unusual Fire/Explosion Hazard:CYLINDERS MAY EXPLODE DUE TO HEAT OF
FIRE.

Spill Release Procedures:LIQUID CARBON DIOXIDE WILL FORM SOLID CO2 (DRY
ICE) WHEN RELEASED TO ATMOSPHERIC PRESSURE. THE AREA SHOULD BE
VENTILATED. CLEAN UP PERSONNEL SHOULD WEAR SELF-CONTAINED BREATHING
APPARATUS WITH FULL FA CE MASK AND HEAVY PROTECTIVE CLOTHING.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN A COOL, WELL-VENTILATED
PLACE. NEVER WORK ON A PRESSURIZED SYSTEM. IF THERE IS A LEAK,
CLOSE THE CYLINDER VALVE AND BLOW DOWN THE SYSTEM.
Other Precautions:KEEP AWAY FROM SOURCES OF HEAT. CAUTION! CAN CAUSE
RAPID SUFFOCATION DUE TO OXYGEN DEFICIENCY. USE WITH ADEQUATE
VENTILATION. CO2 IS HEAVIER THAN AIR AND TENDS TO ACCUMULATE NEAR
THE FLOOR IN CLOSED S PACES. READ ALL INSTRUCTIONS.

Respiratory Protection:NONE REQUIRED UNDER NORMAL USE. HOWEVER,
AIR-SUPPLIED RESPIRATORS ARE REQUIRED WHILE WORKING IN CONFINED
SPACES WITH THIS PRODUCT. THE RESPIRATORY PROTECTION USE MUST
CONFORM WITH OSHA RULES AS SPECIF IED IN 29 CFR 1910.134.
Ventilation:SUFFICIENT TO PREVENT ACCUMULATION ABOVE TLV. LOCAL EXHAUST
LOCATED NEAR THE FLOOR.
Protective Gloves:INSULATED AND COLD RESISTANT NEOPRENE
Eye Protection:SAFETY GOGGLES OR GLASSES
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER,
INDUSTRIAL-TYPE WORK CLOTHING, SAFETY SHOES AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health

HCC:G3
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:-109F SUBLI
Vapor Pres:44255
Vapor Density:1.53
pH:ACIDIC
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:VERY SOLUBLE
Appearance and Odor:COLORLESS, ODORLESS GAS; SHIPPED AS A LIQUEFIED GAS
UNDER ITS OWN VAPOR PRESSUR
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
REACTIVE METALS (MAGNESIUM, ALUMINUM), HYDRIDES, MOIST CESIUM OXIDE OR
LITHIUM ACETYL
Stability Condition to Avoid:OVERHEATING CYLINDERS
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXYGEN WHEN HEATED ABOVE 1700C.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. DO NOT ATTEMPT TO DISPOSE OF RESIDUAL OR
UNUSED QUANTITIES. RETURN IN THE SHIPPING CONTAINER PROPERLY
LABELED, WITH ANY VALVE OR CAPS SECURED TO AIRCO FOR PROPER
DISPOSAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.